Product ID:ARMOSTAT 310
MSDS Date:05/13/1997
FSC:6810
NIIN:00N091551
Status Code:A
MSDS Number: CJLZY

AKZO NOBEL CHEMICALS INC

300 S. RIVERSIDE PLAZA
CHICAGO, IL 60606
US

Emergency Phone: 914-693-6946

Info Phone: 800-828-7929

Preparer: PROD SFTY (914-674-5000)

Cage: 97854

AKZO NOBEL CHEMICALS INC

CHICAGO, IL 60606-6613 US

Telephone: 800-828-792

Cage: 97854

N,N-BIS(2-HYDROXYETHYL)(TALLOW ALKYL)AMINE;

CAS: 61791-44-4

OSHA PEL N/K

ACGIH TLV: N/K

TALLOWALKYLAMINES

CAS: 61790-33-8

OSHA PEL N/K

ACGIH TLV: N/K

ETHOXYLATED TALLOW ALKYL AMINES; (ETHOXYLATED

CAS: 61791-26-2

RTECS: KO9625000

OSHA PEL N/K

ACGIH TLV: N/K

LD50 LC50 Mixture:LD50 (ORAL RAT): APPROX 1350 MG/KG.
Routes of Entry: Inhalation:NO Skin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NO OSHA:NO
Health Hazards Acute and Chronic:ACUTE: INHALATION: DUE TO ITS LOW
VAPOR PRESSURE, THIS PRODUCT IS NOT LIKELY TO PRESENT AN INHALATION
HAZARD AT NORMAL TEMPERATURES. AT ELEVATED TEMPERATURES, VAPORS
&/OR FUMES MAY CAUSE IRRITATION OF RESPIRATORY TRACT. SKIN:
CONTACT CAN CAUSE SEVERE IRRITATION/BURNS W/REDNESS, SWELLING, &
BLISTERING. PROLONGED/REPEATED CONTACT MAY CAUSE ALLERGIC SKIN
REACTION IN SENSITIVE INDIVIDUALS. INGESTION: CAN CAUSE SEVERE
IRRITATION/BURNS OF MOUTH, THROAT, ESOPHAGUS, & STOMACH. CHRONIC:
INHALATION: CHRONIC INHALATION EXPOSURE EFFECTS ARE NOT KNOWN.
(EFFECTS OF OVEREXPOSURE)
Effects of Overexposure:HEALTH HAZARDS: BECAUSE OF ITS LOW VAPOR PRESS,
SIGNIFICANT AMOUNTS OF AIRBORNE VAPORS ARE NOT EXPECTED AT NORMAL
ROOM TEMPS. HOWEVER, USE AT ELEVATED TEMPS MAY GENERATE VAPORS
WHICH ARE IRRITATING TO RESPIRATORY TRACT. SKIN: CHRONIC
DERMALEXPOS EFFECTS ARE NOT KNOWN. HOWEVER, CONTACT CAN CAUSE
SEVERE IRRITATION/BURNS W/REDNESS, SWELLING, & BLISTERING.
PROLONGED/REPEATED CONT MAY CAUSE ALLERGIC SK IN REACTION IN
SENSITIVE INDIVIDUALS. EYES: SEVERELY IRRITATING & CORROSIVE TO
EYES. INGESTION: CHRONIC INGESTION EFFECTS ARE NOT KNOWN. HOWEVER,
INGEST CAN RESULT IN SEVERE IRRITATION/BURNS OF MOUTH, THROAT,
ESOPHAGUS & STOMACH.
Medical Cond Aggravated by Exposure:THERE ARE NO DATA AVAILABLE THAT
ADDRESS MEDICAL CONDITIONS THAT ARE GENERALLY RECOGNIZED AS BEING
AGGRAVATED BY EXPOSURE TO THIS PRODUCT.

First Aid:INHAL: UNLIKELY; HOWEVER, IF IT DOES OCCUR, REMOVE TO FRESH
AIR. IF NOT BRTHG, GIVE ARTF RESP. IF BRTHG IS DFCLT, ADMIN OXYGEN.
GET MED ATTN. SKIN: IMMED REMOVE CONTAM CLTHG & SHOES. REMOVE MATL
FROM SKIN BY PATTING/BLOTTING W/CLEAN CLOTH. DO NOT WIPE/RUB MATL
FROM SKIN. FLUSH REMAINING MATL FROM SKIN W/WATER, & THAN WASH SKIN
THORO W/SOAP & PLENTY OF WATER FOR AT LEAST 15 MINS. DO NOT ATTEMPT
TO NEUT W/CHEM AGENTS. GET MED ATTN. WASH CONTAM CLTHG BEFORE
REUSE. THORO CLEAN CONTAM SHOES BEFORE REUSE/DISCARD AS NEC. EYES:
IMMED FIRST AID IS REQUIRED TO PVNT EYE DMG. IF WEARING CONT
LENSES, REMOV E THEM. (SUP DAT)

Flash Point Method:COC
Flash Point:=210.C, 410.F
Extinguishing Media:USE WATER SPRAY, DRY CHEMICAL, CARBON DIOXIDE, OR
FOAM EXTINGUISHING AGENTS. DIRECT APPLICATION OF HIGH PRESSURE
WATER STREAMS MAY SPLATTER BURNING MATERIAL.
Fire Fighting Procedures:WEAR NIOSH APPRVD SCBA & FULL PROT EQUIP . AS
IN ANY FIRE, PVNT HUMAN EXPOS TO FIRE, SMOKE, FUMES/PRODS OF
COMBUST. EVACUATE NON-ESSENTIAL PERS FROM FIRE AREA. IF POSS REMOVE
CONTRS FROM FIRE AR EA. KEEP FIRE-EXPOSED CONTRS COOL W/WATER
FOG/SPRAY TO PVNT RUPTURE DUE TO EXCESS HEAT. (SARA REGS)
Unusual Fire/Explosion Hazard:PROD IS NOT DEFINED AS FLAM/COMBUST.
HOWEVER, UNDER FIRE CNDTNS IT MAY SUPPORT COMBUST & DECOMP TO GIVE
OFF TOX GASES SUCH AS CARBON MONOXIDE & DIOXIDE, & NITROGEN OXIDES.
PROD IS NOT SENSITIVE TO STA TIC DISCHARGE. OXIDES OF CARBON &
NITROGEN ARE PRDCED BY COMBUST. NFPA RATINGS: HLTH: 3, FLAM: 1;
REACTIVITY: 0.

Spill Release Procedures:ISOLATE SPILL AREA & RESTRICT NON-ESSENTIAL
PERS FROM AREA. ALL PERS INVOLVED IN SPILL CLEAN-UP SHOULD FOLLOW
GOOD INDUS HYGIENE PRACTS. WEAR PROT CLTHG TO PVNT SKIN & EYE CONT.
STOP SOURCE OF SPILL I F THIS IS POSS W/OUT BEING INJURED.
SWEEP/SCOOP UP SPILLED MATL. IF LIQUIFIED, ABSORB W/INERT MATL
(E.G. SAND/EARTH). REMOVE & PLACE IN CHEM WASTE CONTR FOR DISP.
FLUSH SPILL AREA W/DETERGENT & WATER.

Handling and Storage Precautions:WEAR PROT EQUIP WHEN HNDLG PROD TO
PVNT EYE & SKIN CONT. USE APPRVD EQUIP FOR TRANSPORT OF CONTRS TO
AVOID PUNCTURING/RUPTURING CONTRS. DO NOT USE AIR PRESS TO EMPTY
CONTRS. EMPTIED CONTRS MAY RETAIN PROD RESIDUES. FOLLOW ALL
WARNINGS & PREC EVEN AFTER CONTR IS EMPTIED.
Other Precautions:STORE AWAY FROM FOODSTUFFS/ANIMAL FEED. CONTRS SHOULD
BE STORED IN COOL, DRY, WELL-VENTILATED AREA AWAY FROM
ACIDIC/OXIDIZING MATLS. OPEN CONTRS SHOULD BE TIGHTLY CLSD WHEN
RETURNED TO STOR. IF OUTDOO R STOR IS UNAVOIDABLE, CONTRS SHOULD BE
PLACED IN AREA SHIELDED FROM SUN & OTHER ELEMENTS. (SARA REG S)

Respiratory Protection:USE OF RESP PROT GEN IS NOT REQUIRED. HOWEVER,
IF USE CNDTNS (E.G., ELEVATED TEMPS) GENERATE VAPS, AEROSOLS/FUMES,
USE NIOSH APPRVD ORG VAP RESP W/DUST, MIST, & FUME FILTERS TO
REDUCE POTENTIAL FOR IN HAL EXPOS. WHERE EXPOS POTENTIAL
NECESSITATES HIGHER LEVEL OF PROT, USE NIOSH APPRVD, POS-PRESS,
PRESS-DEMAND, AIR-SUPPLIED RESP. (SARA REGS)
Ventilation:SPECIAL VENT IS USUALLY NOT REQUIRED UNDER NORM USE
CONDITIONS. GEN PLANT VENT SHOULD BE ADEQUATE IN MOST CASES. USE
LOCAL EXHAUST AT ELEVATED TEMPS (>200C).
Protective Gloves:IMPERVIOUS GLOVES (NEOPRENE OR NITRILE RUBBER
RECOMMENDED).
Eye Protection:ANSI APPROVED CHEMICAL WORKERS GOGGLES AND FULL LENGTH
FACESHIELD .
Other Protective Equipment:EYEWASH & DELUGE SHOWER MTG ANSI DESIGN
CRITERIA . SKIN CONT MUST BE PREVENTED THRU USE OF IMPERVIOUS CLTHG
& FOOTWEAR SELECTED W/REGARD FOR USE CNDTN EXPOS POTENTIAL.
NEOPRENE/NITRILE RUBBER REC.
Work Hygienic Practices:WASH THOROUGHLY AFTER HANDLING.
Supplemental Safety and Health
FIRST AID PROC: TAKE CARE NOT TO CONTAM VICTIM'S HEALTHY SKIN & EYES.
IMMED FLUSH EYES W/LGE QTYS OF RUNNING WATER FOR AT LEAST 15 MINS.
HOLD EYELIDS APART DURING FLUSHING TO ENSURE RINSING OF ENTIRE
SURF OF EYE & LIDS W/WATER. DO NOT LET VICTIM RUB EYES. DO NOT
ATTEMPT TO NEUT W/CHEM AGENTS. (OTHER INFO)

Boiling Pt:=300.C, 572.F
B.P. Text:@ 760 MM HG (MINIMUM)
Melt/Freeze Pt:=32.C, 89.5F
M.P/F.P Text:APPROXIMATELY
Vapor Pres:0.1 MM HG @ 20C
Spec Gravity:0.916 @ 25C
pH:N/K, ALKALINE
Evaporation Rate & Reference:1 (BUTYL ACETATE=1)
Solubility in Water:NEGLIGIBLE
Appearance and Odor:YELLOW PASTE WITH TYPICAL AMINE ODOR.
Percent Volatiles by Volume:1% (WT)

Stability Indicator/Materials to Avoid:YES
THIS PRODUCT IS INCOMPATIBLE WITH STRONG ACIDS AND STRONG OXIDIZERS.
Stability Condition to Avoid:AVOID PRLNG STOR AT ELEVATED TEMPS. NOT
SELF-REACTIVE & HAS A SHELF LIFE OF GREATER THAN 1 YR UNDER SEALED
CNDTNS. IT IS NOT SENSITIVE TO PHYSICAL IMPACT/STATIC DISCHARGE.
Hazardous Decomposition Products:THERMAL DECOMPOSITION PRODUCTS INCLUDE
TOXIC OXIDES OF CARBON AND NITROGEN.

Waste Disposal Methods:MATL THAT CANNOT BE USED/CHEM REPROCESSED &
EMPTY CONTRS, EXCEPT THOSE DESIGNED FOR MULTIPLE USE (RETURNABLE),
SHOULD BE DISPOSED OF I/A/W ALL APPLIC REGS. PROD CONTRS SHOULD BE
THORO EMPTIED BEFORE D ISP. THIS PROD, IF UNUSED, IS NOT A RCRA
LISTED WASTE & DOES NOT MEET RCRA CRITERIA OF HAZ WASTE BY
CHARACTS. (TRANSPORT INFO)

Toxicological Information:SEE HLTH HAZS SECTIONS. INHAL: ALTHOUGH DATA
EXISTS FOR PROD, STUDY DOES NOT REFLECT NORM USE/POTENTIAL EXPOS
CNDTNS. DERMAL: THIS MATL WAS SEV IRRITATING & CORR TO RABBIT SKIN
FOLLOWING 4-HR EXPOS. E YES: SEV IRRITATING & CORR TO EYES. INGEST:
IN A 90 DAY FEEDING STUDY, THE NOEL (NO OBSERVED EFT LEVEL) IN
BEAGLE DOGS WAS 13 MG/KG. IN A 60 DAY FEEDING STUDY, THE NOEL IN
ALBINO RATS WAS 500 MG/KG. C ARCIN PROPERTIES FOR THIS MATL ARE NOT
KNOWN. MATL WAS NOT MUTAGENIC IN AMES TEST. REPRO TOX & NEUROTOX
EFTS OF PROD ARE NOT KNOWN. NO OTHER TOX EFTS FOR THIS PROD ARE
KNOWN. TARGET ORGANS: OVEREXP MA Y AFFECT SKIN, EYES & DIGESTIVE
TRACT.

Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.

Ecological:ECOTOX INFO: ECOLOGICAL TOX NOT KNOWN. HOWEVER, THE
FOLLOWING DATA EXIST FOR RELATED MATL: ZEBRA FISH: LC50 (96
HRS)=0.39 MG/L (NOMINAL CONC; HIGHLY TOX). DISTRIBUTION: OTHER
ECOLOGICAL INFO ON PROD N OT KNOWN. CHEM FATE: PROD IS READILY
BIODEGRADABLE BY CLSD BOTTLE TEST. OTHER INFO: NOTE TO MD:
ATTENDING MD SHOULD TREAT EXPOSED PATIENTS SYMPTOMATICALLY. CHEM
BURNS ON SKIN SHOULD BE TREATED AS THER MAL BURNS. SKIN RXNS MAY
TAKE 24-48 HRS TO DEVELOP. FLUSH EYES W/BUFFERED OR PLAIN
IRRIGATING SOLNS. IF ANY ULCERATION/CONJ INJURY IS PRESENT, HAVE
OPHTHALMOLOGIST EXAMINE PATIENT. ICED WATER HELPS RE LIEVE PAIN &
SWELL OF BOTH SKIN & EYES.

Transport Information:SHIPPING DESCRIPTION: AMINES, SOLID, CORR, N.O.S.
(ALKOXYLATED FATTY AMINES); 8, UN3259, PG III, NORTH AMERICAN EMER
RESPONSE GUIDE # 154. REQUIRED LABELS: CORR. ENVIRON HAZ SUBSTANCE:
PROD DOES NOT C ONTAIN ENVIRON HAZ SUBSTANCE PER 49 CFR 172.101,
APPENDIX A. --WASTE DISP METH: WASTE GENERATORS ARE REQUIRED TO
EVALUATE ALL WASTE MATL FOR COMPLIANCE W/RCRA & ANY LOC DISP PROC &
REGS. DISPOSE OF WA STE I/A/W LOC, STATE, & FED REGS. INCIN MAY BE
USED WHERE PERMITTED BY REGS. NOTE: STATE & LOC REGS MAY BE MORE
STRINGENT THAN FED REGS. CONTR DISP: CONTRS SHOULD BE CLEANED OF
RESIDUAL PROD BEFORE DI SP. (SARA REGS)

SARA Title III Information:FIRE FIGHT PROC: HIGH PRESS WATER MAY SPREAD
PROD FROM BROKEN CONTRS INCREASING CONTAM/FIRE HAZ. DIKE FIRE WATER
FOR LATER DISP. DO NOT ALLOW CONTAM WATER TO ENTER WATERWAYS. OTHER
PREC: EXERCISE DUE CAUTION TO PVNT DMG TO/LEAKAGE FROM CONTR. MAX
STOR TEMP; 100.40 F (38.00C), AMBIENT (BULK-W/IN2 BLANKET). KEEP
CONTRS TIGHTLY CLSD UNTIL READY FOR USE. DO NOT REUSE CONTR. RESP
PROT: WHEN USING RESP CARTRIDGES/CANISTERS, THEY MUST BE CHANGED
FREQUENTLY (FOLLOWING EACH USE/AT END OF WORKSHIFT) TO ASSURE
BREAKTHRU EXPOS DOES NOT OCCUR. TRANSPORT INFO: EMPTY CONTRS SHOULD
BE DISPOSED OF I/A/W ALL AP PLIC LAWS & REGS.
State Regulatory Information: